Specifications
Engine
Cummins 4BT3.9-G4 turbocharged 4 cylinder diesel standard.
Meets EPA Mobile Off Highway, California CARB requirements.
Frequency Control
Woodward digital electronic controller with integrated actuator.
No external linkage to maintain. Crystal accuracy for HMI lighting.
Controller
Engine control, AC monitoring, fault and pre-fault systems are provided by a microprocessor-based system. All readouts are digital and are listed below. Weather-proof glass cover.
|
Monitoring |
Faults and Pre-Faults |
|
AC Voltage - All Legs |
Oil Pressure Fault/Pre-Fault |
|
Amperage - All Legs |
Water Temp Fault/Pre-Fault |
|
Frequency - All Legs |
Over Crank Fault |
|
Oil Pressure |
Over Speed Fault |
|
Water Temperature |
Low Fuel Fault and Pre-Fault |
|
Battery Voltage |
Low Battery Pre-Fault |
|
Fuel Level |
Defective Oil Sending Unit Pre-Fault |
|
Time To Next Service |
Defective Water Sending Unit Pre-Fault |
Generator
Lima/Marathon MagnaPLUS 94KW with Single Phase/Three Phase Switch. Provides full 500A@120V output in Single Phase and in Three Phase. Marine rated rectifier with surge suppression.
CSA listed.
Voltage Regulator
Lima/Marathon SE 350 with remote voltage adjustment.
UL and CSA listed.
Circuit Breaker
250 amp breaker protects equipment in either single or three phase. Weather-proof glass cover. UL and CSA listed.
Electrical Connection
2 rows of UL listed Cam-Lok type connectors with male and female grounds. 2 Edison 20A outlets with separate breakers provided for convenience outlets. Engine block heater connection.
NEC approved panel.
Size/Weight
With Trailer: Length: 154", Width: 86", Height: 72"
Without Trailer: Length: 96", Width: 36", Height: 50"
Weight: Trailer, generator, and fuel: 3500 lbs. (1590 kg)
Weight: Generator and fuel: 3000 lbs. (1363 kg)
Noise Level
Less than 50 db(A) @ 50 feet.
|
Optional Accessories
Remote Annunciator
Provides remote monitoring of engine and generator with the same readouts as controller. Includes any length cable up to 50'.
Cable up to 1700 yards available. Size: 3" T, 5.5" W, 5" D.
Pow-R-Con Paralleling System without vacuum contactor
"The most advanced, comprehensive paralleling solution available today." Four functions in one:
- Display and Programming Panel
- Isochronous Load Sharing
- Auto-Synchronizer
- Load Management
Remote Annunciator with Remote Start
Provides remote monitoring of engine/generator and remote start/stop.
Electronic Service Kit
Provides total redundancy of all electronic parts. Each component can be installed in less than ten minutes. Includes:
- Barber-Colman Controller
- Magnetic Pick-up
- Engine/Generator Controller Board Set
- Voltage Regulator
- Voltage Adjust Pot
480 Volt
277/480 Volt 3 phase in addition to standard voltages.
Trailer
Single Dexter Torflex axle, 15" aluminum wheels, electric brakes or surge hydraulic brakes, 4-position coupler (with choice of 2" ball, 2-5/16" ball or Pintle hook), DOT lighting, 3500 lbs. (1588 kg) GVW. Includes spare tire.
Truck Mount with Fork Pockets
For mounting directly to truck chassis, flat bed or any flat surface. Allows lifting with forklift from end of generator.
Fuel Tank
60 Gallon tank is standard.
| Load |
Run Time |
| 500A |
14:45 |
| 375A |
18:45 |
| 250A |
25:20 |
| 125A |
42:00 |
|
|
Burrell Enterprises, Inc.
3526 Lakeview Parkway #177, Suite B, Rowlett, TX 75088
Phone: (972) 475-8111 - Toll Free (866) 474-8111 or (800) 474-8111 - bob@litepower.com
Copyright (C) 2004 Burrell Enterprises, Inc., All Rights Reserved
|
LitePOWER Main Menu
Click
here to download the LitePOWER 60KW Generator Specifications